<input id="e4w28"><tt id="e4w28"></tt></input>
  • <center id="e4w28"><code id="e4w28"></code></center>
  • <rt id="e4w28"><small id="e4w28"></small></rt>
    <div id="e4w28"></div>
    <li id="e4w28"></li>
  • <object id="e4w28"></object>
  •  
     
    網站首頁 公司簡介 新品推薦 產品展示 新聞中心 人才招聘 信息反饋 聯系我們 友情鏈接  
    flash2
    反饋:

    滾動文字

     
     
    無錫市華通液壓氣動制造有限公司
    地址:無錫市東北塘鎮農垻村農石路楊家橋
    聯系人:朱先生  13906198250
    電 話:0510-88201238、88203666
    傳 真:0510-88700320
    網 址:www.basiloglue.com 
     
     您當前位置:墻板機首頁>新聞中心

    墻板機的維護保養

    作者:匿名    訪問量:2633    發布時間:2013/9/13

    1、除每班向墻板機振動導桿內加注黃油和對有關部件進行檢查、調整、清洗、加油等常規保養外,還應定期做好如下保養工作;按實際工作時間計算,累計運行1800小時,需要換一次減速箱內的潤滑油,加入新油前應用煤油或柴油將減速箱內清洗干凈。定期檢查減速箱油位,若接近下限應立即補至上限。按規定夏季加入HL—30齒輪油,冬季加入HL---20齒輪油,嚴禁不同牌號的齒輪油混合使用。油封失效漏油時,應及時更換油封,
    2、墻板機的振動器應按以下規定進行保養;A、振動器在搬運和操作時,應注意輕放,防止敲擊損壞。B、機殼外表應保持清潔,以免妨礙電機散熱。C、振動器運轉中如發現不正常的聲響或不正常的振動情況以及焦臭味應立即斷開電源,停機檢查。D、滾動軸承潤滑脂采用復合鈣基脂,注意定期清洗,在振動器動運轉150~200小時更換一次,涂量不可過多,以充填軸承空腔三分之一為宜,以免軸承發熱。E、定期檢查軸承、油封設備等易損件的磨損情況,如發現問題必須及時更換。
    3、墻板機擠壓運行中,若出現制板質理差和成型速度嚴重下降時,應停機檢查攪刀、墻板、振動板等易損件;更換攪刀時,應做到對稱更換,以保證送料均勻。
    4、墻板機不得漏天放置,長期不用時,關健部位應涂油保護,并使兩個前行走輪和兩個后墻板四角觸地,水平放置,以減少變形。
    5.除按照本說明書的規定使用保養外,用戶還應制定擠壓機的安全操作規程,實行定員操作,確保該機的正常運行,以生產出合格的制品。

    1, in addition to filling inside every to guide wall plate vibration butter and inspection on relevant parts, adjustment, cleaning, gas, such as regular maintenance, also should do the following maintenance work on a regular basis; According to the actual working time calculation, the accumulative running 1800 hours, need to change a slowdown in the lubricating oil, add new oil before application of kerosene or diesel will slow down the clean in the cabinet. Regularly check reducer oil level, if close to the lower limit shall be immediately to the ceiling. In accordance with the provisions in the summer to join - 30 HL gear oil, winter to join the HL - 20 gear oil, it is forbidden to different type of gear oil mix. Oil spill, oil seal failure change oil seal in time,
    2, wall plate vibrator should be in accordance with the following provisions of maintenance; A, vibrator in handling and operation, should pay attention to light put, prevent damage of tapping. B, chassis appearance should be kept clean, in order to avoid obstruction of motor cooling. C, vibrator motion such as found in the abnormal sound or abnormal vibration and coke smell immediately disconnect the power, the stop check. D, rolling bearing grease with composite calcium base grease, regular cleaning, pay attention to in the shaker dynamic change from 150 to 200 hours, with not too much, with a third bearing cavity filling advisable, to avoid bearing heating. E, regularly check the bearing, oil seal, such as wear and tear on parts, such as found that the problem must be timely replacement.
    3, wall plate extrusion operation, if a poor quality of plate and molding speed serious decline, should stop to check parts, such as mixing blade, wall plate, vibration plate; Replace the mixing blade, should be symmetrical replacement, to ensure uniform feeding.
    4, wall plate shall not leak days placed, long-term need not when, key parts should be greased protection, and make the two former walking wheel and two corners touch the ground after the wallboard, horizontal, in order to reduce deformation.
    5. In addition to the use and maintenance in accordance with the provisions of this manual, the user should also formulate extrusion machine safety operation procedures, and execute complement operation, ensure the normal running of the machine, in order to produce qualified products.

     

    網站首頁 | 公司簡介 | 新品推薦 | 產品展示 | 新聞中心 | 人才招聘 | 信息反饋 | 聯系我們 | 友情鏈接

    抗震支架 LED顯示屏 智慧燈桿 臥式球磨機 粉末冶金 金卡紙 模袋 刮泥機 異型鋼管 直讀光譜儀 空調風機 清洗機 尾礦 活塞環 麻辣海鮮 高效過濾器 液壓系統 攪拌球磨機 端面銑床

    版權所有:無錫市華通液壓氣動制造有限公司   無錫網站建設:無錫速聯科技
    友情鏈接: 伺服油缸  電機換熱器  太陽能污水處理設備 一體化預制泵站

    <input id="e4w28"><tt id="e4w28"></tt></input>
  • <center id="e4w28"><code id="e4w28"></code></center>
  • <rt id="e4w28"><small id="e4w28"></small></rt>
    <div id="e4w28"></div>
    <li id="e4w28"></li>
  • <object id="e4w28"></object>
  • 白俄罗斯美女高潮喷水_韩国19禁a片在线观看_igao网站在线观看_男人边吃奶边做好爽免费视频